Researchers at the Institute of Industrial Science, The University of Tokyo, have developed a desktop charger with voltages high enough to replenish the electric charge on N95 and surgical masks, which is required for effective use
CREDIT: Institute of Industrial Science, The University of Tokyo
Get home, take off your mask and toss it in the bin. This daily ritual might change soon, however, thanks to scientists from the Institute of Industrial Science at The University of Tokyo.
The researchers have developed a compact system that can restore N95 respirators and surgical masks that have been exposed to moisture to 97% efficiency. By using a special circuit and a conductive plate, a large and uniform voltage distribution recharges the mask in about one minute. This machine can help address the need for high-performance masks while reducing plastic medical waste.
During the recent COVID-19 pandemic, surgical masks and N95 respirators were in high demand, because these were some of the best tools available for reducing the risk of catching or transmitting the SARS-CoV-2 virus. Remarkably, the pore size of these masks, about 10 microns, is much larger than the size of virus-carrying aerosol droplets, which are about one micron. However, the reason the masks are still so good at capturing droplets is that the polypropylene mesh inside them carries a static electric charge, which can attract the droplets via electrostatic force.
However, over time or as a mask becomes wet, this effect becomes significantly reduced, hindering effectiveness. “Humidity, including exposure to exhaled air, or washing in water removes a mask’s charge and compromises its filtering efficiency,” says lead author Taisuke Ikawa. As a result, most used masks were discarded, instead of being sterilized and reused.
The device built by the research team is based on an electrical circuit called a Cockcroft-Walton’s voltage multiplier. This allows electrical potentials of up to 40,000 volts to be obtained in a compact device. The researchers used a conductive aluminum plate as an electrode to ensure a homogenous voltage distribution, and covered it with an insulating plastic PET board to suppress sparks.
The efficiency of the masks was tested after being washed in water; efficiency was significantly restored after brief exposure to the electric field generated by the device. “Our work raises the possibility that masks can be sterilized and recharged again and again, significantly increasing supply,” says senior author Kaori Sugihara. Future research may scale up the size of the device to help increase throughput.
Original Article: Renewing COVID masks
More from: University of Tokyo
The Latest Updates from Bing News
Go deeper with Bing News on:
Covid masks
- Student protesters in masks could face felony charges under anti-KKK law in Ohio
Protesters around the U.S. and the world have increasingly taken steps to remain anonymous by wearing a combination of head and face covering.
- North Carolina lawmaker looking to peel back COVID-era provision being used in protests
Republican state Sen. Buck Newton is pushing a bill in the North Carolina legislature that would repeal a COVID-era provision allowing the broad use of masks.
- Ohio attorney general warns student protesters in masks could face felony charges under anti-KKK law
Not all do so to hide their identities, however. Some wear religious hijabs or medical masks used to prevent exposure to COVID-19, or as a political statement on the virus' ongoing impacts. Yost, a ...
- Flu case decline brings end to NY mask mandate for unvaccinated health care workers
Health care personnel who are unvaccinated against the flu no longer must wear masks at work, the state Health Department announced Wednesday, citing how influenza is on the decline in New York State ...
- Here’s How Long the CDC Says to Isolate if You Test Positive for COVID in 2024
If you test positive for COVID-19 or have respiratory virus symptoms (like a fever ... During that isolation period, it's best to wear a high-quality, well-fitting mask, like an N95 mask, when you ...
Go deeper with Bing News on:
Reusing single use masks
- Reusable PPE is here - and it's designed specifically for women in STEM
AmorSui just launched a line of sustainable PPE products, including gender-inclusive lab coats, reusable isolation gowns, and fire-resistant hijabs.
- Are Disposable Hotel Slippers the Next Plastic Straws?
Slippers supplied by hotels — flimsy models usually made of plastic and fabric — are the next single-use item in the cross hairs of sustainability activists.
- The Best Reusable Eye Masks For Puffiness And Dark Circles
Unlike disposable options made from single-use materials like thin plastic or paper, brands like Dieux Skin and Pacifica craft reusable eye masks from more resilient materials such as silicone.
- What would it take to ditch single-use plastic?
For reuse to succeed ... almost all single-use plastic in packaging, other forms of single-use plastic—like the gloves and masks that became ubiquitous during the pandemic—need to be designed ...
- The 15 Best Under Eye Masks for Men
We’ve all had those mornings. Whether it’s after a night of insomnia or an especially wild party, waking up with puffy, swollen eyes, dark raccoon-like circles or dry, saggy bags has happened ...