An efficient method to harvest low-grade waste heat as electricity may be possible using reversible ammonia batteries, according to Penn State engineers.
“The use of waste heat for power production would allow additional electricity generation without any added consumption of fossil fuels,” said Bruce E. Logan, Evan Pugh Professor and Kappe Professor of Environmental Engineering. “Thermally regenerative batteries are a carbon-neutral way to store and convert waste heat into electricity with potentially lower cost than solid-state devices.”
Low-grade waste heat is an artifact of many energy-generating methods. In automobiles, waste heat generated in winter is diverted to run the vehicle heating system, but in the summer, that same waste heat must be dissipated to the environment. Coal, nuclear and other power plants require high heat to produce electricity, but after producing electricity the excess waste heat is routed to cooling towers to dissipate. Many industrial sites, geothermal sources or solar generating plants also create low-grade heat that is wasted.
The researchers want to take this waste heat and capture it to produce more power. Other researchers have tried a variety of methods, but most produce too little power to be workable, or they cannot provide a continuous resource. Logan and his team are using a thermally regenerated ammonia-based battery that consists of copper electrodes with ammonia added only to the anolyte — the electrolyte surrounding the anode.
“The battery will run until the reaction uses up the ammonia needed for complex formation in the electrolyte near the anode or depletes the copper ions in the electrolyte near the cathode,” said Fang Zhang, postdoctoral fellow in environmental engineering. “Then the reaction stops.”
This type of battery would be useless as a constant source of electricity if the reaction were not regenerative. Using low-grade waste heat from an outside source, the researchers distill ammonia from the effluent left in the battery anolyte and then recharge it into the original cathode chamber of the battery.
The chamber with the ammonia now becomes the anode chamber and copper is re-deposited on the electrode in the other chamber, now the cathode, but formerly the anode. The researchers switch ammonia back and forth between the two chambers, maintaining the amount of copper on the electrodes.
“Here we present a highly efficient, inexpensive and scalable ammonia-based thermally regenerative battery where electrical current is produced from the formation of copper ammonia complex,” the researchers report in the current issue of Energy and Environmental Science. They note that the ammonia liquid stream can convert the thermal energy to electrical energy in the battery. “When needed, the battery can be discharged so that the stored chemical energy is effectively converted to electrical power.”
Read more: Low-grade waste heat regenerates ammonia battery
The Latest on: Ammonia battery
[google_news title=”” keyword=”Ammonia battery” num_posts=”10″ blurb_length=”0″ show_thumb=”left”]
via Google News
The Latest on: Ammonia battery
- Aza Power wants to swap diesel for ammonia in trucks, tractors, and moreon April 30, 2024 at 12:30 am
If produced using renewable energy, ammonia could significantly reduce emissions from industrial applications.
- EDF Group, J-Power and Yamna consortium awarded a 1 Mtpa green ammonia project in Omanon April 29, 2024 at 9:27 pm
The consortium intends to install approximately 4.5 GW of wind and solar capacity coupled with battery storage . EDF Group, J-Power and Yamna consortium awarded a 1 Mtpa green ammonia project in Oman ...
- EDF Group-led consortium to develop large-scale green ammonia project in Omanon April 29, 2024 at 9:13 pm
The consortium will have the right to build, operate and maintain the project for 47 years. A consortium composed of Electricité de France S.A. and its subsidiary EDF Renewables (EDF Group), Electric ...
- Hydrogen’s transformative potential as a fuel source for carson April 29, 2024 at 9:14 am
In the quest for carbon neutrality, Battery Electric Vehicles get all the hype. But does hydrogen offer unsung potential? Chris Farnell reports.
- The end of hydrogen is this new ammonia engine: 90% lower emissions and freezing temperatureson April 24, 2024 at 5:00 pm
Who knows if this ammonia engine will end up being the historic milestone that the industry has wanted to set for years and that was foreseen with the electrics. After all, it could be the solution to ...
- Amogy partners with Hanwha on ammonia-powered vessel solutionson April 24, 2024 at 6:54 am
A three-way partnership between Brooklyn, N.Y., headquartered Amogy and two units of South Korea’s Hanwhat Group aims to accelerate accelerate the decarbonization of the maritime industry through the ...
- Hanwha Ocean invests into ammonia technology with Amogyon April 24, 2024 at 5:22 am
Korean shipbuilder Hanwha Ocean has partnered with sibling company Hanwha Aerospace to use technology from ammonia-to-power business Amogy in a fuel cell system to power ships with ammonia.
- Ammonia was used to chill huge Finley cold storage warehouse. Where did it go in the fire?on April 24, 2024 at 5:00 am
Black smoke billowing from the cold storage warehouse fire in Finley this weekend carried burning plastic and other potentially toxic building materials into the air, including anhydrous ammonia.
- To lower emissions, a Minnesota startup wants to convert diesel engines to burn ammoniaon April 23, 2024 at 3:00 am
Ammonia doesn’t emit carbon dioxide when burned, but its energy-intensive production mostly relies on fossil fuels, so its benefits depend on sourcing “green” ammonia from renewable power.
- BHP says it aims to receive first ammonia-fuelled bulk carrier in 2026on April 21, 2024 at 10:47 pm
Australia's BHP Group is planning to receive its first ammonia-fuelled bulk carrier in 2026 as part of the company's plans to cut shipping emissions, a senior executive said.
via Bing News