Rice scientists lead production of superhydrophilic membrane to clean fluids for reuse
A new filter produced by Rice University scientists has proven able to remove more than 90 percent of hydrocarbons, bacteria and particulates from contaminated water produced by hydraulic fracturing (fracking) operations at shale oil and gas wells.
The work by Rice chemist Andrew Barron and his colleagues turns a ceramic membrane with microscale pores into a superhydrophilic filter that “essentially eliminates” the common problem of fouling.
The researchers determined one pass through the membrane should clean contaminated water enough for reuse at a well, significantly cutting the amount that has to be stored or transported.
The work is reported in Nature’s open-access Scientific Reports.
The filters keep emulsified hydrocarbons from passing through the material’s ionically charged pores, which are about one-fifth of a micron wide, small enough that other contaminants cannot pass through. The charge attracts a thin layer of water that adheres to the entire surface of the filter to repel globules of oil and other hydrocarbons and keep it from clogging.
A hydraulically fractured well uses more than 5 million gallons of water on average, of which only 10 to 15 percent is recovered during the flowback stage. “This makes it very important to be able to re-use this water,” Barron said.
Not every type of filter reliably removes every type of contaminant, he said.
Solubilized hydrocarbon molecules slip right through microfilters designed to remove bacteria. Natural organic matter, like sugars from guar gum used to make fracking fluids more viscous, require ultra– or nanofiltration, but those foul easily, especially from hydrocarbons that emulsify into globules. A multistage filter that could remove all the contaminants isn’t practical due to cost and the energy it would consume.
“Frac water and produced waters represent a significant challenge on a technical level,” Barron said. “If you use a membrane with pores small enough to separate, they foul, and this renders the membrane useless.
“In our case, the superhydrophilic treatment results in an increased flux (flow) of water through the membrane and inhibits any hydrophobic material – such as oil – from passing through. The difference in solubility of the contaminants thus works to allow for separation of molecules that should in theory pass through the membrane.”
Barron and his colleagues used cysteic acid to modify the surface of an alumina-based ceramic membrane, making it superhydrophilic, or extremely attracted to water. The superhydrophilic surface has a contact angle of 5 degrees. (A contact angle of 0 degrees would be a puddle.)
The acid covered not only the surface but also the inside of the pores, and that kept particulates from sticking to them and fouling the filter.
In tests with fracking flowback or produced water that contained guar gum, the alumna membrane showed a slow initial decrease in flux — a measure of the flow of mass through a material — but it stabilized for the duration of lab tests. Untreated membranes showed a dramatic decrease within 18 hours.
The researchers theorized the initial decrease in flow through the ceramics was due to purging of air from the pores, after which the superhydrophilic pores trapped the thin layer of water that prevented fouling.
“This membrane doesn’t foul, so it lasts,” Barron said. “It requires lower operating pressures, so you need a smaller pump that consumes less electricity. And that’s all better for the environment.”
Learn more: Filter may be a match for fracking water
The Latest on: Fracking
[google_news title=”” keyword=”Mengla virus” num_posts=”10″ blurb_length=”0″ show_thumb=”left”]
via Google News
The Latest on: Fracking
- Deadly Powassan tick virus confirmed in Sharon, Massachusettson April 26, 2024 at 2:07 pm
TICKS FOR THE FIRST TIME. A CONFIRMED CASE OF POWASSAN VIRUS IN SHARON. EXPERTS SAY THE TICK BORNE DISEASE IS MUCH RARER THAN LYME, BUT IT CAN BE DANGEROUS AND EVEN DEADLY. THE PEOPLE THAT I’VE ...
- Bird flu virus traces found in 1 in 5 samples of pasteurized milk: FDAon April 26, 2024 at 11:15 am
According to William Schaffner, professor in the division of infectious diseases at the Vanderbilt University School of Medicine, pasteurization should kill the virus, and people generally shouldn ...
- Bird flu virus traces detected in 1 in 5 pasteurized cow milk sampleson April 26, 2024 at 9:19 am
The agency's testing revealed small genetic traces of bird flu and not live virus that causes infections. Deposit Photos SHARE Genetic material from a particularly virulent strain of bird flu ...
- Traces of bird flu are showing up in cow milk. Here’s what to knowon April 25, 2024 at 10:09 am
News that bird flu has been spreading between cows for months and that fragments of the virus are even showing up in milk on U.S. grocery store shelves have fueled new worries about the risk the ...
- Christina Applegate contracts virus after eating food contaminated with fecal matteron April 24, 2024 at 1:21 pm
Christina Applegate was still recovering from her first run-in with COVID-19 when another virus recently had her health in the toilet again. The “Dead to Me” star spoke humorously — and ...
- Traces of bird flu virus have been found in milk. What's going on? Is dairy safe?on April 24, 2024 at 9:34 am
Fragments of the virus that causes bird flu have been found in samples of pasteurized milk, the Food and Drug Administration said Tuesday, but officials aren't concerned about danger to humans ...
- Remnants of bird flu virus found in pasteurized milk: FDAon April 24, 2024 at 8:08 am
The US Food and Drug Administration said Tuesday that samples of pasteurized milk had tested positive for remnants of the bird flu virus that has infected dairy cows. The agency stressed that the ...
- Christina Applegate Says She Wore Diapers After Contracting Virus from Tainted Saladon April 23, 2024 at 8:54 pm
John Shearer/Getty Christina Applegate is getting candid about how she ended up needing to wear diapers after contracting a virus from a tainted salad. Applegate, 52, recalled the health ...
- Traces of bird flu virus found in some milk and pasteurized dairy, FDA sayson April 23, 2024 at 6:29 pm
In an update from the FDA, the agency said it tested milk samples by polymerase chain reaction (PCR) and found the presence of fragments of the virus, which is not the same as infectious virus and ...
- Fragments of Bird Flu Virus Discovered in Milkon April 22, 2024 at 4:59 pm
Over the last month, a bird flu virus known as H5N1 has been detected in more than 30 dairy herds in eight states. The virus is also known to have infected one farmworker, whose only symptom was ...
via Bing News