Figure 1: Schematics of the FlyGrid system from grid to vehicle.
The figure below shows a simplified circuit diagram of the FlyGrid system. The heart of the idea is the flywheel energy storage device, consisting of a spinning mass (rotor) connected to a high efficient motor-generator as described in figure 2.
The power inverter, which controls the electric machine of the FESS is connected to a DC voltage link. Power can be fed from the grid into the flywheel, through an AC/DC converter (plus power factor controller), or directly to the EV if desired. On the “vehicle side” of the system, custom power electronics allows either DC or AC charging, depending on the capabilities of the vehicle. The high charging power peaks are supplied by the FESS and – depending on the configuration of the motor generator – could reach values of several hundred kW! The current is transmitted to the vehicle via the fully automated, innovative MATRIX CHARGING® system by easelink, which was invented (and is still being developed) in Austria.
While the Austrian electricity mix has a significant share of renewables (~70 %) due to the abundancy of hydro power, this is not the case in other countries. FlyGrid allows the integration of highly volatile local renewables (wind, solar) etc. for instance by using the roofs of carports for PV installation. To avoid transmission and power conversion losses, the local renewable electricity can be fed directly into the DV voltage link of the flywheel and either be stored for later use or routed to the EV for immediate charging.
The FlyGrid system is governed by a high-level controller, which receives information from the following modules: · Electric vehicle: AC vs. DC charging type, state of charge, power demand etc. · Flywheel: State of charge, state of health · Electric grid: Voltage, current and frequency · Electricity supplier: Demand side management commands With this information the controller can operate the system in such way that grid loads are minimized and renewables are used in the most efficient way.
Another benefit is that – if the electricity supplier demands it – the FESS can either feed power back into the grid or be charged when excess energy is available. The ultra-fast reaction time of the flywheel power electronics (~milliseconds) allows nearly instantaneous compensation when the grid frequency drops, which can be crucial for avoiding blackouts.
Enhanced grid stability and power quality through the introduction of inertia in the grid are positive side-effects of FlyGrid. One may argue that with only limited power available to charge up the FESS, it would take long to recharge after the flywheel has spun down during the EV charging cycle. While this is true to a certain extent, it must be mentioned that the EV charge power is only at its maximum at the very beginning of the charge cycle (“constant current mode”) and then drops (“constant voltage mode”) until it reaches “trickle charging” during the last 5 ~15 % of the EV battery’s state of charge. From this, three important conclusions can be drawn: a) The actual energy content that must be stored in the FESS is much lower than the energy content of the EV battery b) The FESS can be charged up again, even when the EV is still plugged in by using the excess power between trickle charging and maximum available grid power c) As a consequence of b), the load on the grid will be completely uniform!
Original Article: Flywheel Energy Storage for EV Fast Charging and Grid Integration
More from: Graz University of Technology
The Latest Updates from Bing News
Go deeper with Bing News on:
Flywheel energy storage system
- Flywheel Energy Storage Market To Spin Up To USD 0.57 Billion By 2031, Fueled By Demand For Reliable And Sustainable Power Solutions
The Asia Pacific region is poised for the fastest growth rate in the Flywheel Energy Storage market. This surge is driven by the factors like abundant availability of resources for flywheel production ...
- US DOE Narrows Scope of Environmental Reviews for Clean Energy Projects
or decommissioning of an electrochemical-battery or flywheel energy storage system within a previously disturbed or developed area or within a small area contiguous to a previously disturbed or ...
- DOE eases environmental review requirements for transmission, storage, and solar projects
DOE said it is taking these steps to reduce the cost and time for environmental analysis incurred by DOE, project developers, and the public for projects.
- Adaptive Balancing Power revolutionizes flywheel technology for high-performance energy storage and charging
Adaptive Balancing Powers MD Dr Hendrik Schaede Bodenschatz standing in front of one of ABP's revolutionary high-performance flywheel energy storage and charging system. Adaptive Balancing Power ...
- Grid-Level Energy Storage And The Challenge Of Storing Energy Efficiently
Utility-level energy storage is essential for not only ... With a few megawatts of strategically placed flywheel- and battery-based systems enough capacity should be available to respond to ...
Go deeper with Bing News on:
FlyGrid system
- Nervous System News
May 6, 2024 — A new study has revealed that areas of age-related damage in the brain relate to motor outcomes after a stroke -- a phenomenon that may be under-recognized in stroke research. The ...
- News tagged with computer system
Vertical farms look hi-tech and sophisticated, but the premise is simple—plants are grown without soil, with their roots in a solution containing nutrients. This innovative approach to ...
- Best system utilities and repair software for business PCs of 2024
Over time all of this stuff has an impact on the system as the disk becomes fragmented, old registry keys get left behind, items are added to startup and more. The same applies to your business ...
- Restore Your PC's Maximum Speed, Power and Stability
* To avoid being charged the recurring subscription fee, simply cancel before the free-trial period ends — it's just $4.99 a month afterwards. The go-to solution for ultimate PC performance and ...
- Revealed: How the F1 2024 standings would look with a new points system
F1 leaders will meet to discuss a potential change to the points system on Thursday but how would that affect the 2024 championship if it was already in place? Any change is unlikely to come into ...