via Drexel University
Researchers in Drexel University’s College of Engineering have developed a thin film device, fabricated by spray coating, that can block electromagnetic radiation with the flip of a switch. The breakthrough, enabled by versatile two-dimensional materials called MXenes, could adjust the performance of electronic devices, strengthen wireless connections and secure mobile communications against intrusion.
The team, led by Yury Gogotsi, PhD, Distinguished University and Bach professor in Drexel’s College of Engineering, previously demonstrated that the two-dimensional layered MXene materials, discovered just over a decade ago, when combined with an electrolyte solution, can be turned into a potent active shield against electromagnetic waves. This latest MXene discovery, reported in Nature Nanotechnology, shows how this shielding can be tuned when a small voltage — less than that produced by an alkaline battery — is applied.
“Dynamic control of electromagnetic wave jamming has been a significant technological challenge for protecting electronic devices working at gigahertz frequencies and a variety of other communications technologies,” Gogotsi said. “As the number of wireless devices being used in industrial and private sectors has increased by orders of magnitude over the past decade, the urgency of this challenge has grown accordingly. This is why our discovery – which would dynamically mitigate the effect of electromagnetic interference on these devices – could have a broad impact.”
MXene is a unique material in that it is highly conductive – making it perfectly suited for reflecting microwave radiation that could cause static, feedback or diminish the performance of communications devices – but its internal chemical structure can also be temporarily altered to allow these electromagnetic waves to pass through.
This means that a thin coating on a device or electrical components prevents them from both emitting electromagnetic waves, as well as being penetrated by those emitted by other electronics. Eliminating the possibility of interference from both internal and external sources can ensure the performance of the device, but some waves must be allowed to exit and enter when it is being used for communication.
“Without being able to control the ebb and flow of electromagnetic waves within and around a device, it’s a bit like a leaky faucet – you’re not really turning off the water and that constant dripping is no good,” Gogotsi said. “Our shielding ensures the plumbing is tight – so-to-speak – no electromagnetic radiation is leaking out or getting in until we want to use the device.”
The key to eliciting bidirectional tunability of MXene’s shielding property is using the flow and expulsion of ions to alternately expand and compress the space between material’s layers, like an accordion, as well as to change the surface chemistry of MXenes.
With a small voltage applied to the film, ions enter – or intercalate – between the MXene layers altering the charge of their surface and inducing electrostatic attraction, which serves to change the layer spacing, the conductivity and shielding efficiency of the material. When the ions are deintercalated, as the current is switched off, the MXene layers return to their original state.
The team tested 10 different MXene-electrolyte combinations, applying each via paint sprayer in a layer about 30 to 100 times thinner than a human hair. The materials consistently demonstrated the dynamic tunability of shielding efficiency in blocking microwave radiation, which is impossible for traditional metals like copper and steel. And the device sustained the performance through more than 500 charge-discharge cycles.
“These results indicate that the MXene films can convert from electromagnetic interference shielding to quasi-electromagnetic wave transmission by electrochemical oxidation of MXenes,” Gogotsi and his co-authors wrote. “The MXene film can potentially serve as a dynamic EMI shielding switch.”
For security applications, Gogotsi suggests that the MXene shielding could hide devices from detection by radar or other tracing systems. The team also tested the potential of a one-way shielding switch. This would allow a device to remain undetectable and protected from unauthorized access until it is deployed for use.
“A one-way switch could open the protection and allow a signal to be sent or communication to be opened in an emergency or at the required moment,” Gogotsi said. “This means it could protect communications equipment from being influenced or tampered with until it is in use. For example, it could encase the device during transportation or storage and then activate only when it is ready to be used.”
The next step for Gogotsi’s team is to explore additional MXene-electrolyte combinations and mechanisms to fine-tune the shielding to achieve a stronger modulation of electromagnetic wave transmission and dynamic adjustment to block radiation at a variety of bandwidths.
More from: Drexel University
The Latest Updates from Bing News
Go deeper with Bing News on:
- MOEN Assorted Gasket Sheet Material
Moen will replace FREE OF CHARGE any part or finish that proves defective in material and manufacturing workmanship, under normal installation, use and service. Replacement parts may be obtained by ...
- Researchers develop neutron-shielding film for radiation protection
An advancement in neutron shielding, a critical aspect of radiation protection, has been achieved. This breakthrough is poised to revolutionize the neutron shielding industry by offering a ...
- Directional-Freezing-Enabled MXene Orientation toward Anisotropic PVDF/MXene Aerogels: Orientation-Dependent Properties of Hybrid Aerogels
Materials Science and Technology Division Council of Scientific and Industrial Research (CSIR)-National Institute for Interdisciplinary Science and Technology (NIIST), Trivandrum 695019, Kerala, India ...
- Supercapacitor Patch Could Solve Power Problem for Wearables
A team from Drexel's College of Engineering—working in collaboration with Accenture Labs—developed the patch using MXene, a carbon-based nano-material discovered by researchers at Drexel that is ...
- Tech: An injection of MXene ink fortifies silicon anodes to absorb charge without terminal swelling — (Report)
Research from Drexel University and Trinity College in Ireland now suggests that an even greater improvement could be in line if the silicon is fortified with a special type of material called MXene.
Go deeper with Bing News on:
Electromagnetic wave jamming
- EW revolution: the US, China, and Europe closely observe Ukraine’s electronic warfare against Russian systems – NYT
“The war in Ukraine has been the performance enhancing drug for NATO’s electromagnetic thinking,” he said ... weapons such as anti-drone guns and small jammers, creating radio-wave bubbles around ...
- The Invisible War in Ukraine Being Fought Over Radio Waves
Using electromagnetic waves to flummox and follow smarter weapons has become a critical part of the cat-and-mouse game between Ukraine and Russia. The United States, China and others have taken note.
- Electromagnetic waves and radar - CCEA
There are seven members of electromagnetic family. The order of electromagnetic waves in the spectrum is shown in the table below.
- What is 'Electromagnetic Waves'
Definition: Electromagnetic waves or EM waves are waves that are created as a result of vibrations between an electric field and a magnetic field. In other words, EM waves are composed of oscillating ...
- Waves - AQA Synergy Electromagnetic waves
Waves are one way in which energy may be transferred between stores. Both mechanical and electromagnetic waves will transfer energy without matter being transferred. Electromagnetic waves travel ...