Proposed method could be more efficient than previous systems and easier to retrofit in existing power plants.
Many researchers around the world are seeking ways to “scrub” carbon dioxide (CO2) from the emissions of fossil-fuel power plants as a way of curbing the gas that is considered most responsible for global climate change. But most such systems rely on complex plumbing to divert the steam used to drive the turbines that generate power in these plants, and such systems are not practical as retrofits to existing plants.
Now, researchers at MIT have come up with a scrubbing system that requires no steam connection, can operate at lower temperatures, and would essentially be a “plug-and-play” solution that could be added relatively easily to any existing power plant.
The new electrochemical system is described in a paper just published online in the journal Energy and Environmental Science, and written by doctoral student Michael Stern, chemical engineering professor T. Alan Hatton and two others.
The system is a variation on a well-studied technology that uses chemical compounds called amines, which bind with CO2 in the plant’s emission stream and can then release the gas when heated in a separate chamber. But the conventional process requires that almost half of the power plant’s low-pressure steam be diverted to provide the heat needed to force the amines to release the gas. That massive diversion would require such extensive changes to existing power plants that it is not considered economically feasible as a retrofit.
In the new system, an electrochemical process replaces the steam-based separation of amines and CO2. This system only requires electricity, so it can easily be added to an existing plant.
The system uses a solution of amines, injected at the top of an absorption column in which the effluent gases are rising from below. The amines bind with CO2 in the emissions stream and are collected in liquid form at the bottom of the column. Then, they are processed electrochemically, using a metal electrode to force the release of the CO2; the original amine molecules are then regenerated and reused.
As with the conventional thermal-amine scrubber systems, this technology should be capable of removing 90 percent of CO2 from a plant’s emissions, the researchers say. But while the conventional CO2-capture process uses about 40 percent of a plant’s power output, the new system would consume only about 25 percent of the power, making it more attractive.
In addition, while steam-based systems must operate continuously, the all-electric system can be dialed back during peak demand, providing greater operational flexibility, Stern says. “Our system is something you just plug in, so you can quickly turn it down when you have a high cost or high need for electricity,” he says.
Another advantage is that this process produces CO2 under pressure, which is required to inject the gas into underground reservoirs for long-term disposal. Other systems require a separate compressor to pressurize the gas, creating further complexity and inefficiency.
The chemicals themselves — mostly small polyamines — are widely used and easily available industrial materials, says Hatton, the Ralph Landau Professor of Chemical Engineering Practice. Further research will examine which of several such compounds works best in the proposed system.
So far, the research team, which also includes former MIT research scientist Fritz Simeon and Howard Herzog, a senior research engineer at the MIT Energy Initiative, has done mathematical modeling and a small-scale laboratory test of the system. Next, they hope to move on to larger-scale tests to prove the system’s performance. They say it could take five to 10 years for the system to be developed to the point of widespread commercialization.
The Latest Bing News on:
CO2 removal
- The start-up transforming carbon dioxide into stoneon March 7, 2021 at 11:04 pm
A start-up in Iceland is tackling a key piece of the climate change puzzle by turning carbon dioxide into rocks, allowing the greenhouse gas to be stored forever instead of escaping into the ...
- U of A scientist co-leads expert U.S. panel on removing carbon from atmosphereon March 7, 2021 at 3:15 am
A University of Alberta scientist is sharing her expertise with policy-makers in the United States in hopes of removing atmospheric carbon dioxide on a mass scale. Associate professor Sasha Wilson and ...
- The Icelandic Startup Bill Gates Uses to Turn Carbon Dioxide Into Stoneon March 6, 2021 at 2:11 pm
Preventing emissions from smokestacks can be done for as little $25 a ton, while pulling them directly from the air can cost $600 a ton.
- Money is pouring into carbon removal technologies, but the companies involved struggle to pay for iton March 6, 2021 at 11:00 am
The dream is to suck carbon from the air and bury it, but the reality is that some direct air capture companies have to sell the captured CO2 to make more oil.
- US earmarks $24mln to research removal of carbon dioxide from air – Energy Depton March 6, 2021 at 10:47 am
The US plans to begin research on potential methods of large-scale extraction of carbon from the atmosphere with $24 million in ...
- Start-up transforming carbon dioxide into stoneon March 6, 2021 at 8:51 am
A start-up in Iceland is tackling a key piece of the climate change puzzle by turning carbon dioxide into rocks, allowing the greenhouse gas to be stored forever instead of escaping into the ...
- DOE invests $24 million to advance transformational air pollution captureon March 5, 2021 at 12:16 pm
The U.S. Department of Energy (DOE) today announced up to $24 million for research into technology that captures carbon emissions directly from the air, replicating the way plants and trees absorb ...
- Canadian briefs U.S. policy-makers on removing CO2 from atmosphereon March 5, 2021 at 4:53 am
A scientist at the University of Alberta is lending her expertise on mineral carbonation to policy-makers in the United States in hopes of reducing atmospheric carbon dioxide on a mass scale. Sasha ...
- Saudi Arabia to Ship Gas to South Korea and Take CO2 Backon March 4, 2021 at 4:27 am
Saudi Arabia may ship gas to South Korea where it will be used to make hydrogen, and the carbon dioxide produced in the process will be transported straight back to the kingdom.
- Join Digital Habitats in the Elon Musk sponsored $100 million Carbon Removal XPRIZEon February 23, 2021 at 4:00 pm
Be part of the solution in cleaning up our planet to help all life on Earth breathe easier. Ask me how you can participate in the restoration of Earth's biosphere.
The Latest Google Headlines on:
CO2 removal
The Latest Bing News on:
CO2 scrubbing system
- The Weekly Planet: Why a Political Philosopher Is Thinking About Carbon Removalon March 3, 2021 at 1:08 pm
Every Tuesday, our lead climate reporter brings you the big ideas, expert analysis, and vital guidance that will help you flourish on a changing planet. Sign up to get The Weekly Planet, our guide to ...
- $100 Hot Water Bottle Pendulum Rebreatheron March 1, 2021 at 4:01 pm
Humans exhale a lot of oxygen along with their waste carbon dioxide ... through the scrubbing material and is stored in hot water bottle counterlung until you inhale. The system is only 15 ...
- Are Schools’ Fancy New Air-Scrubbing Devices Really Effective—and Safe?on March 1, 2021 at 3:00 am
As more schools and businesses prepare to safely reopen, they’re looking for ways to purify indoor air—and the market has answered with a dizzying array of devices that go far beyond traditional HVAC ...
- Grimaldi Sees CO2 Reduction of Up to 43% From New Multipurpose Shipson February 24, 2021 at 5:19 am
Shipping company the Grimaldi Group has agreed to add another six scrubber-equipped vessels to its fleet that may reduce emissions by up to 43%. Grimaldi has ordered six new ro/ro multipurpose vessels ...
- Ranchers can fight global climate change, one acre at a timeon February 13, 2021 at 4:00 pm
Some see salvation in high technology, including the “capture” of CO2 at its source followed by its storage underground, or the “scrubbing ... to planned grazing systems using livestock ...
- Metal Foam Market projected to exceed $96.5 million by 2027, Says Global Market Insights Inc.on February 11, 2021 at 1:08 am
Likewise, metal foam is also used in several aerospace components such as air oil separate, baffle, CO2 scrubber, acoustics, filter, flame arrester, cryogenic tank, etc. This would directly ...
- New Material Inexpensively Removes CO2 from Gas, Scientists Claimon February 8, 2021 at 4:00 pm
Current processes for removing CO2 involve chemical scrubbing, a costly procedure in which the carbon ... solar energy in the atmosphere and damaging Earth's delicate climate system, with potentially ...
- Calnetix Technologies Supplies Key Components for NASA's Next-Generation CO2 Removal Systemon February 2, 2021 at 3:00 am
The design and development of the Four Bed Carbon Dioxide Scrubber (4BCO2 ... line blower is an integral component of the CO2 removal system and will drive the airflow through the entire system ...
- ISGEN: In-Situ Genetics Experiments on Nanosatelliteson January 4, 2017 at 9:40 am
The system is fully self-contained and autonomous ... medium and a humidified air volume to exchange with the microwells via a permeable membrane. CO2 scrubbing and/or O2 generation are provided as ...